2003 330xia- Is there any history on this type of problem(s)

Hello,

I thought I'd put this out there to others who have the knowledge and the
history of this engine.

These are the symptoms we are experiencing with our 330xi automatic (M54 B30
engine). I may actually be describing more than one problem?

1. engine starts fine when cold with the exception that 25-50% of the time I
hear something like metal to metal rotary contact (problem# 1). I have read
about the Double Vanos o-rings that are supposedly the wrong material but I
find it hard to believe BMW hasn't corrected that in the 2003.

2. engine is difficult to start when warm (problem# 2). When hot it starts
fine, it's only when sitting say 25-35 minutes in real cold weather or 40-50
minutes in warmer weather is it hard to start without touching the e-gas
petal a bit.

3. there occasionally is a slight polymer odor when the car has been running
hot. oring?, coolant? synthetic Mobil 1 engine oil? I am not sure.

4. I do want to mention this. Last fall I did attempt to replace all of the
coolant before my maintenance manual had arrived. I opened the radiator
removed the cap and bleed screw next to the cap and received what I thought
was a less than full amount. Because the weather was turning bad I figured
there must be another bleed screw and a partial change was better than
nothing. So I topped off the radiator with what I believed was the
equivalent of what I drained out. After driving the first time and the car
cooling I checked the radiator and overflow. I think I had to add a little
to the over flow but just that once. So now it's 4-5 months later and I
noticed that the overflow has dropped approximately a 1/2 inch. I am
thinking head gasket but shouldn't I be getting a lot of white exhaust at
startup and/or chocolate milk engine oil?

This car has only 24,000 mi and has not been abused, I tend to drive fast
but not rough (jerking the car around). We are the only owners, bought from
a dealer, I believe it had some test drive miles on it, but we should have
seen this earlier if damage was done from abusive test drives.

If anyone has any ideas or history with the double vanos, head gaskets,
heated thermostat that may help, I would appreciate hearing about them.

Thanks,

Mike


.

Relevant Pages

  • Re: 94 Explorer VIN X V6 runs for a minute and dies
    ... bright when the car is running as when the car is cranking but dead. ... Can you keep the engine running indefinitely if you keep spraying the ... allowing them to dispense the fuel? ... If I hear the clicking do I still need to do the lamp test? ...
    (rec.autos.makers.ford.explorer)
  • NASCAR RULES...no es verdad ?
    ... GENERAL CAR AND BODY REQUIREMENTS ... Car must be strictly stock. ... The stock floor pan, fire walls, trunk, trunk floor, (see fuel ... DETAILED ENGINE REQUIREMENTS ...
    (rec.autos.sport.nascar)
  • Re: OT: Blast From The Past - steam - hot and cold
    ... Cold engine powers car with efficiency ... Cylinder injection of a heat transfer fluid followed ... steam power being the most obvious ...
    (alt.guitar.amps)
  • Re: Is Sirius available in Mr. Bean cars?
    ... How about a car that runs on water, ... (they convert 100% of the potential power of the electricity to ... the power in the system between the gas engine, two generators, ... electricity in the batteries consumed by the low-speed acceleration. ...
    (alt.fan.howard-stern)
  • Re: Citroen talk (was:Re: OK, So What Do You Do?)
    ... be censoring me because they intend to compete in the old Maserati ... Deauville, but a lovely car for all of that, and despite the pimptastic ... it wasn't attended to the moment it started going wrong, the engine ...
    (rec.audio.tubes)